Communications - Scientific Letters of the University of Zilina 2018, 20(3):24-29 | DOI: 10.26552/com.C.2018.3.24-29

Electrochemical Characterization of Az31 Magnesium Alloy Treated by Ultrasonic Impact Peening (Uip)

Daniel Kajanek1, Branislav Hadzima2, Filip Pastorek2
1 Department of Materials Engineering, Faculty of Mechanical Engineering, University of Zilina, Slovakia and Research Centre, University of Zilina, Slovakia
2 Research Centre, University of Zilina, Slovakia

Electrochemical characteristics of AZ31 magnesium alloy after impacting by ultrasonic impact peening (UIP) were measured in order to evaluate its effect on corrosion resistance of mentioned alloy. For this purpose, potentio-dynamic polarization (PD) tests and electrochemical impedance spectroscopy (EIS) of ground and impacted samples were performed in 0.1 M NaCl solution at the temperature of 22±2 °C after 5 minutes of potential stabilization. The obtained PD curves were analysed using the Tafel extrapolation method and data from EIS measurements in form of Nyquist plots were quantified by the equivalent circuit method. The results showed clearly that application of the UIP significantly deteriorated corrosion resistance of AZ31 alloy in the chosen testing solution.

Keywords: magnesium alloy; corrosion; ultrasonic impact peening

Received: April 30, 2018; Accepted: May 30, 2018; Published: September 30, 2018  Show citation

ACS AIP APA ASA Harvard Chicago Chicago Notes IEEE ISO690 MLA NLM Turabian Vancouver
Kajanek, D., Hadzima, B., & Pastorek, F. (2018). Electrochemical Characterization of Az31 Magnesium Alloy Treated by Ultrasonic Impact Peening (Uip). Communications - Scientific Letters of the University of Zilina, 20(3), 24-29. doi: 10.26552/com.C.2018.3.24-29
Share...
Download citation
  • BibTeX (.bib)
  • Bookends (.ris)
  • EasyBib (.ris)
  • EndNote (.enw)
  • EndNote 8 (.xml)
  • ISI WoS (.isi)
  • Medlars (.medlars)
  • Mendeley (.ris)
  • MODS (.xml)
  • Papers (.ris)
  • RefWorks (.txt)
  • RefManager (.ris)
  • RIS (.ris)
  • MS Word (.xml)
  • Zotero (.ris)
    • Open full article

    References

    1. MARUYAMA, K., SUZUKI, M., SATO, H.: Creep Strength of Magnesium-Based Alloys. Metallurgical and Materials Transactions A, 33, 875-882, 2002. https://doi.org/10.1007/s11661-002-0157-7 Go to original source...
    2. MENG, X., WU, R., ZHANG, M., WU, L., CUI, CH.: Microstructures and Properties of Superlight Mg-Li-Al-Zn Wrought Alloys. Journal of Alloys and Compounds, 486, 722-725, 2009. https://doi.org/10.1016/j.jallcom.2009.07.047 Go to original source...
    3. DARGUSCH, M. S., PETTERSEN, K., NOGITA, K., NAVE, M. D., DUNLOP, G. L.: The Effect of Aluminium Content on the Mechanical Properties and Microstructure of Die Cast Binary Magnesium-Aluminium Alloys. Materials Transactions, 47(4), 977-982, 2006. https://doi.org/10.2320/matertrans.47.977 Go to original source...
    4. JUN, C., QING, Z., QUAN-AN, L.I.: Effect of Y and Ca Addition on the Creep Behaviors of AZ61 Magnesium Alloys. Journal of Alloys and Compounds, 686, 375-383, 2016. https://doi.org/10.1016/j.jallcom.2016.06.015 Go to original source...
    5. BUKOVINOVA, L., BUKOVINA, M., PASTOREK, F.: Influence of Microstructural Features on the Corrosion Behaviour of AZ91 Alloy in Chloride Media. Materials Engineering - Materialove inzinierstvo, 21, 153-158, 2014.
    6. ATRENS, A., SONG, G.-L., LIU, M., SHI, Z., CAO, F., DARGUSCH, M. S.: Review of Recent Developments in the Field of Magnesium Corrosion. Advanced Engineering Materials, 17(4), 400-453, 2015. https://doi.org/10.1002/adem.201400434 Go to original source...
    7. FRIEDRICH, H. F., MORDIKE, B. L.: Magnesium Technology, 1st edition. Springer, New York, 2006.
    8. ABBOT, T. B.: Magnesium: Industrial and Research Developments over the Last 15 years. Corrosion, 71(2), 120-127, 2015. https://doi.org/10.5006/1474 Go to original source...
    9. GUSIEVA, K., DAVIES, C. H. J., SCULLY, J. R., BIRBILIS, N.: Corrosion of Magnesium Alloys: The Role of Alloying. International Materials Reviews, 60, 169-194, 2014. https://doi.org/10.1179/1743280414Y.0000000046 Go to original source...
    10. SONG, G. L.: Corrosion of Magnesium Alloys, 1st edition. Woodhead Publishing, Philadelphia, 2011. Go to original source...
    11. ATRENS, A., DIETZEL, W.: The Negative Difference Effect and Unipositive Mg. Advanced Engineering Materials, 9(4), 292-297, 2007. https://doi.org/10.1002/adem.200600275 Go to original source...
    12. ESMAILY, M., SVENSSON, J. E., FAJARDO, S., BIRBILIS, N., FRANKEL, G.S., VIRTANEN, S., ARRABAL, R., THOMAS, S., JOHANSSON, L. G.: Fundamentals and Advances in Magnesium Alloy Corrosion. Progress in Materials Science, 89, 92-193, 2017. https://doi.org/10.1016/j.pmatsci.2017.04.011 Go to original source...
    13. CZERWINSKI, F.: Magnesium Alloys-Corrosion and Surface Treatments, 1st edititon. InTech, Rijeka, 2011. Go to original source...
    14. BIRBILIS, N., KING, A. D., SINU, T., FRANKEL, G., SCULLY, J. R.: Evidence for Enhanced Catalytic Activity of Magnesium Arising from Anodic Dissolution. Electrochimica Acta, 132, 277-283, 2014. https://doi.org/10.1016/j.electacta.2014.03.133 Go to original source...
    15. LAMAKA, S. V., HOCHE, D., PETRAUSKAS, R. P., BLAWERT, C., ZHELUDKEVICH, M. L.: A New Concept for Corrosion Inhibition of Magnesium: Suppression of Iron Re-Deposition. Electrochemistry Communications, 62, 5-8, 2016. https://doi.org/10.1016/j.elecom.2015.10.023 Go to original source...
    16. IZQUIERDO, J., FERNANDEZ-PEREZ, B. M., FILOTAS, D., ORI, Z., KISS, A., MARTIN-GOMEZ, R. T., NAGY, L., NAGY, G., SOUTO, R. M.: Imaging of Concentration Distributions and Hydrogen Evolution on Corroding Magnesium Exposed to Aqueous Environments Using Scanning Electrochemical Microscopy. Electroanalysis, 28, 1-14, 2016. https://doi.org/10.1002/elan.201600265 Go to original source...
    17. APELFELD, A., KRIT, B., LUDIN, V., MOROZOVA, N., VLADIMIROV, B., WU, R. Z.: The Characterization of Plasma Electrolytic Oxidation Coatings on AZ41 Magnesium Alloy. Surface and Coatings Technology, 322, 127-133, 2017. https://doi.org/10.1016/j.surfcoat.2017.05.048 Go to original source...
    18. KAJANEK, D., PASTOREK, F., FINTOVA, S., BACA, A.: Study of Corrosion Behavior of Dicalcium Phosphate-Dihydrate (DCPD) Coating Prepared by Large Amplitude Sinusoidal Voltammetry (LASV) Technique on ZW3 Magnesium Alloy. Proceedia Engineering, 192, 399-403, 2017. https://doi.org/10.1016/j.proeng.2017.06.069 Go to original source...
    19. OMASTA, M., HADZIMA, B., PASTOREK, F.: Study of Calcium Phosphate (OCP) Electrodeposition Process on Elektron 21 Magnesium Alloy Surface. Materials Science Forum, 818, 115-120, 2015. https://doi.org/10.4028/www.scientific.net/MSF.818.115 Go to original source...
    20. MALAKI, M., DING, H.: A Review of Ultrasonic Peening Treatment. Materials and Design, 87, 1072-1086, 2015. https://doi.org/10.1016/j.matdes.2015.08.102 Go to original source...
    21. DONG, Z., LIU, Z., LI, M., LUO, J. L., CHEN, W., ZHENG, W., GUZONAS, D.: Effect of Ultrasonic Impact Peening on the Corrosion of Ferritic-Martensitic Steels in Supercritical Water. Journal of Nuclear Materials, 457, 266-272, 2015. Go to original source...
    22. MORDYUK, B. N., PROKOPENKO, G. I.: Ultrasonic Impact Peening for the Surface Properties' Management. Journal of Sound and Vibration, 308, 855-866, 2007. https://doi.org/10.1016/j.jsv.2007.03.054 Go to original source...
    23. RODOPOULOS, C. A., PANTELAKIS, S. G., PAPADOPULOS, M. P.: The Effect of Ultrasonic Impact Treatment on the Fatigue Resistance of Friction Stir Welded Panels. Journal of Materials Engineering and Performance, 18(9), 1248-1257, 2009. https://doi.org/10.1007/s11665-009-9385-y Go to original source...
    24. FENG, Y., HU, S., WANG, D., CUI, L.: Formation of Short Crack and its Effect on Fatigue Properties of Ultrasonic Peening Treatment S355 Steel. Materials and Design, 89, 507-515, 2016. https://doi.org/10.1016/j.matdes.2015.10.009 Go to original source...
    25. VOORT, G. F. V.: ASM Handbook Vol. 9: Metallography and Microstructures. ASM International, New York, 2004.
    26. RAI, X. J., NISHIMURA, T.: Studies on Galvanic Corrosion of Iron-Magnesium Couple by Scanning Electrochemical Microscopy in 0.1 M NaCl Solution. Journal of Industrial and Engineering Chemistry, 41, 141-150, 2016. https://doi.org/10.1016/j.jiec.2016.07.020 Go to original source...
    27. KAJANEK, D., HADZIMA, B., PASTOREK, F., NESLUSAN JACKOVA, M.: Electrochemical Impedance Spectroscopy Characterization of ZW3 Magnesium Alloy Coated by DCPD Using LASV Deposition Technique. Acta Metallurgica Slovaca, 23(2), 147-154, 2017. https://doi.org/10.12776/ams.v23i2.900 Go to original source...
    28. AMIRUDIN A., THIERRY D.: Application of Electrochemical Impedance Spectroscopy to Study the Degradation of Polymer-Coated Metals. Progress in Organic Coatings, 26(1), 1-28, 1996. Go to original source...
    29. GHALI, E.: Corrosion Resistance of Aluminium and Magnesium Alloys, 1st edition. John Wiley & Sons Inc., New Jersey, 2010. https://doi.org/10.1002/9780470531778 Go to original source...
    30. MHAEDE, M., PASTOREK, F., HADZIMA, B.: Influence of Shot Peening on Corrosion Properties of Biocompatible Magnesium Alloy AZ31 Coated by Dicalcium Phosphate Dihydrate (DCPD). Materials Science and Engineering C, 39, 330-335, 2014. https://doi.org/10.1016/j.msec.2014.03.023 Go to original source...
    31. ZHOU, J., YANG, Y., FRANK, M.A., DETSCH, R., BOCCACCINI, A.R., VIRTANEN, S.: Accelerated Degradation Behavior and Cytocompatibility of Pure Iron Treated with Sandblasting. Applied Materials and Interfaces, 8, 26482-26492, 2016. https://doi.org/10.1021/acsami.6b07068 Go to original source...

    This is an open access article distributed under the terms of the Creative Commons Attribution 4.0 International License (CC BY 4.0), which permits use, distribution, and reproduction in any medium, provided the original publication is properly cited. No use, distribution or reproduction is permitted which does not comply with these terms.


    Return to the content